A DIVISION OF
O-Z/GEDNEY A UNIT OF GENERAL SIGNAL
PART NUMBER AA-545, 546, 547, 548, &
549 (FB-725 CPS)
| COMPANY
ADDRESS Nelson Firestop Products 4041 S. Sheridan Road Tulsa, Oklahoma 74145 Telex 216459 Phone number 8-AM to 5-PM (918) 627-5530 or 1-800-331-7325 |
DATE PREPARED
10/21/93 REVISION NO. 5 REVISION DATE 01/13/98 PREPARED BY Nelson Firestop Eng. |
|
| SECTION 1 -
MATERIAL IDENTIFICATION AND INFORMATION |
||
| Description
Synthetic Urethane Sodium Silicate Zinc Oxide Chlorinated Paraffin Melamine |
CAS No.
Range
9017-09-8 1344-09-08 13144-12-2 63449-39-8 108-78-1 |
Weight
Percent
48-82% 12-23% 3-9% 6-11% 7-13% |
| SECTION 2 -
PHYSICAL / CHEMICAL CHARACTERISTICS |
||
| Boiling
Point:
Specific Gravity: Vapor pressure (mmHg) and Temperature: Melting Point : Vapor density (Air = 1): Evaporation rate: Appearance: Odor: |
>800°C
@68°F = 1.4 Solid
Not established Solid Light gray None |
|
| SECTION 3 - FIRE AND EXPLOSION HAZARD DATA | ||
| Flash
point:
Auto-ignition: Flammability Limits in Air: Extinguisher Media:
|
Not
Flammable
Not established LEL: (N/A) UEL: (N/A) For surrounding combustibles water, spray fog or stream - foam, or inert gas CO2. Large fire, use water fog, spray or stream. Thermal decomposition of surrounding materials may create toxic fumes; Protective fire fighting equipment is recommended. Unusual Fire and Explosion Hazards: Same as above. |
|
| SECTION 4 - ACTIVITY HAZARD DATA | ||
| Stability:
Conditions to avoid: Incompatibility (Materials to avoid): Hazardous Polymerization: |
Stable
None As a normal precaution, strong mineral acids and or agents should be avoided. Will not occur. |
|
| SECTION 5 - HEALTH HAZARD DATA | ||
| Primary Route of
entry:
Carcinogen Listed in: Health Hazards: Signs and Symptoms of Exposure: Medical Conditions Aggravated by Exposure: |
Ingestion
Inhalation.
Not listed. Acute - None Noted Chronic - None Noted Normal contact is by skin (hands). Material is normally cleaned from hands with out effect. None established. |
|
| EMERGENCY FIRST AID PROCEDURES: Seek medical attention as required. | ||
| Eye
contact:
Skin Contact: Inhalation: Ingestion: |
Flush with
water Wash
with soap and water. Remove
to fresh air. As with
swallowing any foreign substance, consult a physician. |
|
| SECTION 6 - CONTROL AND PROTECTIVE MEASURES. | ||
| Respirator
Protection:
Protective Gloves: Eye Protection: Ventilation to be used: Other Protective clothing and Equipment: Hygienic Work Practices: |
Not normally
required.
As required. As required. Local Exhaust. As
required to meet local industrial Industrial hygiene and safety practices should be observed. |
|
| SECTION 7 -
PRECAUTIONS FOR HANDLING AND USE - LEAK PROCEDURES. |
||
| Steps to be taken
if material is spilled or released:
Waste disposal methods: Other precautions and or Special Hazards: |
Use common
clean-up procedures
Protect
from weather extremes. |
|
| Although the information and recommendations given are believed correct at the time of issuance, Nelson Firestop Products makes no representation or warranty as to its completeness or accuracy. Nelson Firestop Products shall in no event be responsible for damages whatsoever directly or indirectly resulting from such information and recommendations. | ||